REFURBISHMENT AND EVALUATION OF A TWO-WHEELED TRACTOR
DOI:
https://doi.org/10.4314/njt.374.1885Keywords:
two-wheel tractor, refurbishment, effective field capacity, field efficiencyAbstract
The refurbishment of GUTBROD-WERKE/80 two-wheeled tractor for better functioning and subsequent field performance evaluation was carried out. Physical and mechanical inspections were done to ascertain the state of the tractor. The observed faults were; rusted and stuck carburetor, damaged induction coil, rusted fuel control, stuck wheels, worn out tires, and no implement attachment base. The faults were corrected by designing coupling flanges for implement attachment; replacement of carburetor and worn-out parts. The tractor was tested by conducting a field evaluation using standard equations and procedure. The results obtained showed that the field efficiency and effective field capacity were 61.50%, and 0.032ha/hr respectively. The fuel consumption was 0.43L/hr at a depth and width of cut of 8.94cm and 27.46cm respectively at an average soil moisture content of 13.2%. The implement draft and drawbar pull were 1.13kN and 0.43kW respectively. The tractor performance shows its suitability for small farm work.
Downloads
Published
Issue
Section
License
The contents of the articles are the sole opinion of the author(s) and not of NIJOTECH.
NIJOTECH allows open access for distribution of the published articles in any media so long as whole (not part) of articles are distributed.
A copyright and statement of originality documents will need to be filled out clearly and signed prior to publication of an accepted article. The Copyright form can be downloaded from http://nijotech.com/downloads/COPYRIGHT%20FORM.pdf while the Statement of Originality is in http://nijotech.com/downloads/Statement%20of%20Originality.pdf
For articles that were developed from funded research, a clear acknowledgement of such support should be mentioned in the article with relevant references. Authors are expected to provide complete information on the sponsorship and intellectual property rights of the article together with all exceptions.
It is forbidden to publish the same research report in more than one journal.